In this April 2014 file image frame grab from video, provided by the Federal Aviation Administration (FAA), a test at the FAAs technical center in Atlantic City, N.J. The U.S. government is urging that large, personal electronic devices like laptops be banned from airline checked luggage because of the potential for a catastrophic fire. (FAA via AP, File)
WASHINGTON – The United States government has urged the world airline community to ban large, personal electronic devices such as laptops from checked-in luggage as they were likely to cause a catastrophic fire.
The Federal Aviation Administration (FAA) said in a paper filed recently with a United Nations agency that tests it conducted showed that when a laptop’s rechargeable lithium-ion battery overheats in close proximity to an aerosol spray can, it can cause an explosion capable of disabling an airplane’s fire suppression system.
The paper likewise specified that the fire could then rage unchecked, and could even lead to “the loss of the aircraft.”
The UN’s International Civil Aviation Organization (ICAO) had set global aviation safety standards but member-countries should still ratify them. The proposed ban is on the agenda of a meeting of ICAO’s panel on dangerous goods held in Montreal.
The FAA has conducted 10 tests involving a fully-charged laptop packed in a suitcase. A heater was placed against the laptop’s battery to force it into “thermal runaway”, a condition in which the battery’s temperature continually rises.
In one test, an 8-ounce aerosol can of dry shampoo, which is permitted in checked baggage, was strapped to the laptop. There was a fire almost immediately and it grew rapidly. The aerosol container exploded within 40 seconds, the FAA noted.
The test showed that because of the rapid progression of the fire, Halon gas fire suppressant systems used in airline cargo compartments would be unable to put out the fire before there was an explosion, the FAA said.
The explosion might not be strong enough to structurally damage the plane, but it could damage the cargo compartment and allow the Halon to escape – then there would be nothing to prevent the fire from spreading, the FAA added.
Other tests of laptop batteries packed with potentially dangerous consumer goods that are permitted in checked luggage like nail polish remover, hand sanitizer, and rubbing alcohol also resulted in large fires, although no explosions, the agency further disclosed.
The paper recommended air companies to disallow large electronic devices in cgecj baggage unless they specifically approved it.
The paper said the European Safety Agency, the FAA’s counterpart in Europe; Airbus, one of the world’s largest makers of passenger airliners; the International Federation of Airline Pilots’ Association; and the International Coordinating Council of Aerospace Industries Association, which represents aircraft makers, concurred in the recommendation.
The document, however, did not tackle whether the ban should extend to domestic flights, but points out the risk that baggage containing a large electronic device could be transferred from one flight to another without the knowledge of the airline.
Rechargeable lithium batteries are used in consumer products ranging from cellphones and laptops to electric cars. Manufacturers like them because they pack more energy into smaller packages, but the batteries can self-ignite if they have a manufacturing flaw, are damaged, exposed to excessive heat, overcharged or packed too closely together. The fires can burn up to 1,100 degrees Fahrenheit, close to the melting point of the aluminum used in aircraft construction.
Since 2006, three cargo jets have been destroyed and four pilots were killed by in-flight fires that investigators said were either started by batteries or made more severe by their proximity.
Earlier this year, the US imposed a ban on laptops in the cabins of planes coming into the country from 10 Middle Eastern airports for security reasons. The ban was fully lifted in July after US officials said airports in the region had taken other steps to increase security.
The Pipeline and Hazardous Materials Safety Administration (PHMSA) formerly led US negotiations on the regulation of dangerous goods at ICAO meetings. But the Obama administration put the FAA in charge in 2009 after congressional Democrats accused high-level officials at PHMSA of being too cozy with the industries they regulate.
Transportation Secretary Elaine Chao has now decided to put PHMSA back in charge at future ICAO dangerous goods deliberations, Rep. Peter DeFazio (D-Ore.) said on Thursday. Both agencies are part of the Transportation Department.
DeFazio called the decision “inexplicable” in a letter to Chao.
“I strongly believe it has the potential to put the lives of airline passengers and crews at serious risk,” he said.
Chao did not immediately respond to a request for comment. Lobbyists for lithium battery makers and companies that use the batteries in their products have previously urged the change. /kga